Cannot the plug-in hybrid handle the winter cold ?
Yesterday I noticed something interesting and at the same time worrying. The EV drive mode did not work properly at -20 degrees celsius (-4 F). Lets start from the beginning …
To heat the interior of the car in winter and cold temperatures the petrol engine has to generate the heat. Now it can feel like a loss to have an electric car that needs to use the gasoline engine in winter. You can then use the pre-heater to heat the cabin before leaving. The heater is using the car’s driving battery to power the heater, therefore it is best to do this during charging so as not to jeopardise the range on EV drive If you have a 16A charger it will charge at the same rate as the pre-heater uses battery. If you have a 10A charger it will not keep up with the required charging.
I usually pre-heat for 30 min and the heat produced lasts for 15 minutes, depending on outside temperature, without additional heat from the petrol engine, especially when using the seat heaters and steering wheel heating.
To ensure that the petrol engine is not enabled you can put the ventilation and heating system in the OFF position.
Yesterday, for the first time this winter the temperature was -20 degrees Celsius (-4 F). I had had my Outlander in garage overnight where the temperature was -6 degrees C (21 F). I used the pre-heat for 30 minutes just before departure. With EV drive only I drove toward Soderhamn, 25 km south and started the ventilation and heating system when I got half way to bring up the heat in the car again. At that time the petrol engine started, as it should. When I reached the desired temperature I turned the ventilation and heating system off again and the petrol engine was shut down and I ran only on EV drive.
During the day the car is parked in Soderhamn in -20 degrees temperatures (-4 F). When I´m, about to leave for home the car is fully charged and before leaving I pre-heated the car in 30 minutes. HOWEVER when I try using the same procedure as before with the ventilation and heating system switched off I didn’t manage to get the petrol engine to stop. The entire trip is made with the engine running and the only time it shuts off for a short period is in a steep downhill. The battery meter shows full but the meter for the estimated range for EV drive shows just three strokes. No numbers. When I get home the battery meter is full. The route I run, I run at a speeds of 40-65 mph. The symbols for energy flow displays the arrows between the gasoline engine and battery and battery to wheel the whole trip. I don’t get why it’s like this, the battery is full so the petrol engine should not have to charge the battery and I have the ventilation off. It has something to do with the battery capacity degradation in severe cold I believe.
This morning it was -10 degrees (14 deg F) outside and I had the car parked in the garage overnight. The battery was not fully charged and I wasn’t running for the heater because I got an error message when I tried to do it. I put a car heater in for 10 min instead. Also this time I was able to make the whole journey in pure EV mode without starting the petrol engine.
When I was leaving for home in the evening, it was -15 degrees (5 deg F), I had preheated the car for 30 min and it was almost fully charged. The petrol engine started in the beginning but after a few minutes I was able to turn off the fan and therefore the petrol engine. It seems that -20 degrees (-4 F) is the limit for the batteries . It says something in the manual that at temperatures below -15 C, there might be a problem with starting and limited power. I also noticed that brake regeneration effect didn´t work as well. The car didn´t slow down as much at B5 like before.
Luckily we don’t have these low temperatures that often.
If you want to leave comments on my posts, there is a comment box below each post. The comments field is not listed on the home page, but you have to go into each post. You get to it by clicking on the title of the post.
Visit Graphic Studio – my company’s website
Photographer Photographer Hudiksvall, Söderhamn